Product ID:TEFLON FINISH, 459-887
MSDS Date:08/11/1989
FSC:8010
NIIN:00N024249
MSDS Number: BMFQM

E I DUPONT DE NEMOURS & CO

1007 MARKET STREET
WILMINGTON, DE 19898
US

Emergency Phone: 800-441-3637;800-424-9300(CHEMTREC)

Info Phone: 800-441-7515

Cage: 0ERJ7

E.I. DUPONT DE NEMOURS & CO

WILMINGTON, DE 19898 US

Telephone: 800-441-7515;800-441-9442

Cage: 18873

OXYGENATED NITROGEN POLYMER

GLYCOLS,POLYETHYLENE,MONO(1,1,3,3-TETRAMETHYLBUTYL)PHENYL)

CAS: 9036-19-5

RTECS: MD0907600

1.

CAS: 100-37-8

RTECS: KK5075000

OSHA PEL 10 PPM,S

ACGIH TLV: 10 PPM,S

1.

CAS: 98-00-0

RTECS: LU9100000

OSHA PEL S, 50 PPM/15 STEL

ACGIH TLV: S,10 PPM/15STEL;9293

0.3.

CAS: 872-50-4

RTECS: UY5790000

SILICON DIOXIDE, AMORPHOUS;(AMORPHOUS SILICA)

CAS: 7631-86-9

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

IRON (III) OXIDE

CAS: 1309-37-1

RTECS: NO7400000

OSHA PEL 10 MG/M3 (FE)

ACGIH TLV: 5 MG/M3(FE),B2; 9293

MANGANESE DIOXIDE; (MANGANESE OXIDE)

CAS: 1313-13-9

RTECS: OP0350000

OSHA PEL 5 MG/M3, C (MN)

ACGIH TLV: 5 MG/M3,DUST (MN)

DO NOT EXCEED REC BAKING TEMPS. AT >400C

RTECS: 9999999ZZ

FLUORIDE IS TOXIC & CAN CAUSE SKIN & EYE IRRIT.

RTECS: 9999999ZZ

FLUOROPOLYMER SOLIDS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:NORMALLY NOT A HAZARD. THESE
PRODS CNTN SMALL AMTS OF SOLVS. EYE:MAY CAUSE BURNING OR
IRRITATION. SKIN:RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT
W/DISCOMFORT & DERM. INGEST:GI DISCOMFORT. REFER TO ORIGINAL MSDS
FOR SPECIFIC HAZARDS OF INDIVIDUAL INGREDS. EXPOS TO TEFLON DECOMP
PRODS CAN CREATE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INFLUENZA-LIKE SYMP COMMONLY REFERRED
TO AS POLYMER FUME FEVER. SYMP DO NOT ORDINARILY OCCUR UNTIL SEV
HRS AFTER EXPOS & PASS W/IN 36-48 HRS. EFTS ARE NOT CUMULATIVE.
EXPOS USUALLY RSLTS FROM SMKNG TOBACCO/CIGARETTES CONTAM WITH
FLUOROCARBON DURING HNDLG OR FROM BRTHG VAP EMITTED DURING BAKING.
(ING 10)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING DIFFICULTY
PERSISTS OR OCCURS LATER, CALL MD. EYE:IMMEDIATELY FLUSH W/PLENTY
OF WATER FOR AT LEAST 15 MINUTES, CALL MD. SKIN:WASH WITH SOAP &
WATER. IF IRRITATION OCCURS, CALL MD. INGEST:CALL MD IMMEDIATELY
AND HAVE NAMES OF INGREDIENTS AVAILABLE.

Flash Point:NONE
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER FROM NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:HYDROGEN FLUORIDE IS RELEASED DURING A
FIRE.

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
AVOID SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE WITH
INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND CNTNRS
WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:EXPLOSIVE REACTION MAY OCCUR ABOVE 796 F W/FINELY
DIVIDED FLUOROCARBON & METAL POWDER (ALUMINUM OR MAGNESIUM). OPERS
SUCH AS GRINDING, BUFFING OR GRIT BLASTING MAY GEN SUCH MIXTURES.
KEEP WET. USE W/A DEQ VENT TO CNTRL. DO NOT (SUPP DATA)

Respiratory Protection:DO NOT BREATHE VAPORS/MISTS. WEAR PROPERLY
FITTED NIOSH/MSHA APPRVD VAP/PART RESP (TC-23C) FOR USE WITH PAINTS
DURING APPLIC & UNTIL ALL VAPS & SPRAY MIST ARE EXHAUSTED. FOLLOW
RESPIRATORY MANUFACTURE RS DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
% VOLAT:63.4-76.6 (WT).OTHER PREC:EXCEED REC BAKING TEMPS. BAKING OVENS
MUST BE PROPERLY VENT. AT TEMPS ABOVE 400C (750F) SMALL AMTS OF HF
CAN BE EVOLVED; AMTS INCR AS TEMP INCRS. HF IS TOX (3 PPM CEI
LING-ACGIH). SOME VEGETATION IS PARTICULARLY SENSITIVE TO DMG BY HF
AND ATTENTION MUST BE GIVEN TO EXHAUST LOCATIONS.

HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.12-1.22
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF HEAVY METALS, HYDROGEN
FLUORIDE.

Waste Disposal Methods:DO NOT ALLOW MATL TO CONTAM GROUND WATER SYS.
SEND TO HAZ WASTE WATER TREATMENT PLANT OR INCIN ABSORBED MATL
I/A/W FED, STATE & LOCAL REQUIREMENT. DO NOT INCINERATE CLOSED
CONTAINERS. DISPOSAL MUST BE IN ACCORDANCE W/ALL LOCAL, STATE &
FEDREGS

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.